The Effect of Ammonia on Growth and Survival Rate of Tilapia rendalli in Quail Manured Tanks  

Masautso E. Sakala , Confred G. Musuka
Natural Resources Development College, Lusaka, Zambia; 2The Copperbelt University, School of Natural Resources, P.O. Box 21692, Kitwe, Zambia.
Author    Correspondence author
International Journal of Aquaculture, 2014, Vol. 4, No. 22   doi: 10.5376/ija.2014.04.0022
Received: 29 Mar., 2014    Accepted: 18 May, 2014    Published: 04 Jun., 2014
© 2014 BioPublisher Publishing Platform
This is an open access article published under the terms of the Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
Preferred citation for this article:

Sakala and Musuka, 2014, The Effect of Ammonia on Growth and Survival Rate of Tilapia rendalli in Quail Manured Tanks, International Journal of Aquaculture, Vol.4, No.22: 1-6 (doi: 10.5376/ija.2014.04.0022)

Abstract

This experiment was conducted to determine the effect of ammonia on growth and survival rate of Tilapia rendalli reared in concrete tanks for 14 weeks using quail manure. It was a completely randomized design (CRD) with five treatments; T1 (control, without quail manure), T2 (0.32kg quail manure/tank/week), T3 (0.40kg quail manure/ tank/week), T4 (0.48kg quail manure/tank/week) and T5 (0.64kg quail manure/tank/ week), replicated two times. Twenty-five fish, with an average individual initial weight of 14 g were stocked per tank, each measuring, 2m × 2m (4m2). Every fortnight individual fish were weighed on a sensitive scale and the length measured on a measuring board to the nearest 0.1 cm. The results of the experiment indicated that fish raised under treatment 4 (T4) grew much faster (ANOVA, P<0.05) than the other groups with weight gain of 246%. T2 had the lowest mean weight gain of 86.08%. The final mean weights ranged from 26.23 g to 47.55 g, while total length ranged from 111mm± 2.29mm to 140.1mm± 2.29mm respectively. The study further revealed that in order to achieve table size growth and survival of fish, 0.48 kg quail manure/week/4m2 should be used as optimum for better growth of fish, although no primary productivity was measured to estimate zooplankton biomass. At the same time,daily growth rate was good and within acceptable range for fish of the same size. Survival rate in all treatments was very high, with the lowest being above 60%.The study further demonstrated that higher amounts of ammonia affected growth and survival of the fish in treatment 5 (T5), a tank with the highest amount of quail manure added per week.

Keywords
Ammonia; Effect; Growth; Survival rate; Quail manure; Concrete tanks
There has been tremendous development in the farming of tilapia worldwide, in which the commodity is not only the second most important farmed fish globally, next to carps but is also described as the most important aquaculture species of the 21st century (Shelton, 2002). The main purpose of fish culture is to raise the fish to table size in the shortest possible time (Lovell, 1989). Tilapia, especially Oreochromis niloticus (Nile tilapia) is reported to be an appropriate species in aquaculture owing to its wide adaptability, and its ability to convert many organic, animal and agriculture wastes into high quality protein (Balarin, 1979). However, the cost of feed still remains high and feed costs make up the largest cost of fish production, hence a challenge to most fish farmers (Steffens, 1989). In all regions of the world, the increase in the cost of raw ingredients for manufactured or on-farm aquafeeds resulted in an increase in aquafeed prices from 20 to 40 percent, thus forcing farmers to adopt alternative strategies to secure feeds (Rana Sunil Siriwardena, and Hasan, 2009). In the light of such price increases, farmers are increasingly looking for alternative sources of feeds such as trash fish, animal by-products and grain by-products, or are reverting to the use of single ingredient supplementary feeding regimes, reduced feeding frequency and ration. These types of interventions to mitigate against rising feed costs will compromise fish growth, health and welfare and could reduce fish productivity and production (Rana Sunil Siriwardena, and Hasan, 2009). The fish feed plays an important role in the value chain as it implies important control of the quality of raw materials, which is crucial for the food safety as well as efficient high quality feed types that ensures optimal growth for different fish species farmed under a variety of different conditions (Thorarinsdottir et al., 2011). The feed cost has to be controlled as this is most often approximately 50% of the total production cost in aquaculture (Thorarinsdottir et al., 2011). In recent years most farmers have engaged in the integration of fish and quail rearing. The use of quail manure as a fertilizer to enhance the growth of phytoplankton in ponds raises a lot of concerns due to ammonia in quail manure which could potentially affect the growth and survival rate of fish, (Jobling, 1994; Durborow et al., 1997). Ammonia toxicity to fish depends on the concentration of unionized ammonia (NH3) (Handy & Poxton, 1993). Percent NH3 increases with temperature and pH. Both temperature and pH increase the NH3 concentration (Nettena et al, 2013). In general, more NH3 and greater toxicity exists at higher pH, which implies that NH3 is more dependent of pH than temperature. This is because the percent of toxic un-ionized NH3 increases with pH (Frank, 1998). NH3 toxicity will become more pronounced under higher temperatures, but that effect on aquatic macrophytes will strongly depend on pH of the water layer and specific metabolic adaptations of different species (Nettena et al, 2013). However, less concentration of this NH3 can be tolerated at lower pH (Frank, 1998).
Materials and Methods
The experiment was conducted in duplicates using 10 × 2m × 2m (4m2) concrete tanks at The National Aquaculture Development and Research Centre (NARDC) in Mwekera for a period of 14 weeks. The ponds were supplied with borehole water that was maintained at constant level throughout the experimental period. Twenty-five fish (Tilapia rendalli), with an average individual initial weight of 14 g and 79.49 mm length, were stocked per tank. Tilapia rendalli fingerlings that were used in the experiment were collected from a 150 m2 hatchery earthen pond located within the fish farm. Fingerlings were acclimatized for a period of one week before the commencement of the experiment. During the acclimatizing period, the fingerlings were fed on maize bran at 4% of their body weight.
Key water quality parameters such as water temperature, pH and dissolved oxygen (DO) were measured twice per day (at 09:00hrs and 15:00hrs), using a Horiba U-10 water quality checker. The checker sensor measures by being directly submersed or dipping the probe 20 cm into the water. Total ammonia-nitrogen was monitored twice a week using standard methods (Tucker, 1993; APHA, 1999).
Every fortnight individual fish were weighed on a sensitive scale and the length measured on a measuring board to the nearest 0.1 cm. For accurate results the fish were starved for 24 hours prior to weighing. The growth of fish was compared in tanks with different amounts of quail manure. Initial and final weight, percent in weight gain, increase in total length, and coefficient of the final weight of individual and condition factor were analyzed using analysis of variance (ANOVA).
The growth parameters were calculated using the following formulae:
Conditional factor (K): The formula is of the form: K=W/L3
Where K = Fulton’s condition factor, W = the weight of the fish, and L is the length (usually total length).
Specific growth rate (SGR), expressed as percent body weight per day, was calculated from: SGR = 100 (ln Wf – ln Wi)/t
Where:-
Wf = final mean weight,
Wi = initial mean weight, and
t = experimental time in days
Percentage increase in weight (IWG %) was computed following the formula provided by De Silva and Anderson (1995): %IWG = (Wf - Wt)/Wt x100
The experiment was a completely randomized design (CRD) with five treatments;T1 (control, without quail manure), T2 (0.32kg quail manure/tank/week), T3 (0.40kg quail manure/ tank/week), T4 (0.48kg quail manure/tank/week) and T5 (0.64kg quail manure/tank/ week), replicated two times.
Statistical package for social sciences (SPSS) version 12.0 software was used in the statistical analysis and variables differences were considered significant at P < 0.05. One–way analysis of variance (ANOVA) was used to test the differences between treatments during the experiment.
Results
As shown in Figure 1, there were differences in the final mean weight gain among the treatment groups. Fish in treatment 4 (T4), with 0.48kg quail manure showed the best (P<0.05) growth performance (Figure 1), with the final average body weight of 47.55g. Slow and inconsistent growth was however, observed in treatments 5 (T5).


Figure 1 Mean body weight of T. rendalli reared in experimental tanks for 14 weeks

Growth trends of Tilapia rendallisupplied with different rate of quail manure are shown in Figure 1. The significant (P<0.05) growth of fish was influenced by the Quail manure application rates at all water temperature. All the treatments showed fast and constant growth during the onset of the experimental period except T5, which had the highest amount of quail manure. Furthermore, after the third week, a pronounced difference in growth rate of fish was observed between the treatment groups and this difference was significant (ANOVA, P<0.05) (Figure 1). However, T1 (control), recorded steady and constant growth throughout the experimental period.
Meanwhile, Table 1 shows the mean final body weight of fish that varied from 26.23g to 47.55g with highly significant differences between treatments (p<0.05).


Table 1 Growth performance of T. rendalli raised under fertilized ponds for 14 weeks

The study showed that Treatments 5 (T5) and 4 (T4) were significantly different from each other while others were not. Final total length ranged from 111mm± 2.29mm to 140.1mm± 2.29mm respectively. Survival rate in all treatments was very high, with the lowest being above 60% (Table 1). The key water quality parameters such as pH, DO, Temperature and Ammonia were not significantly different among the treatment groups (ANOVA, P > 0.05, Table 2).


Table 2 Water quality parameters during 14 weeks experimental period (Mean ±SE)

The average water temperature was 22.44 °C, while pH varied between 7.30±0.12 and 7.81±0.16 across all the treatments. The minimum and maximum DO concentration varied between 5.98±0.33mg L-1 and 6.13±0.36 mg L-1 across all treatments, respectively. The unionized ammonia varied between 0.0057 mg L-1 and 0.0354 mg L-1.
Discussion
From the results presented above, there were differences in the growth of fish in all the treatments. The differences in growth and survival were mainly due to the different levels of ammonia in the water. Rapid and slow growth was observed in T4 (0.48 kg quail manure/week) and 5 (0.64kg/ quail manure/tank/week) respectively.
The study demonstrated that higher amounts of ammonia affected growth and survival of the fish in treatment 5 (T5), a tank with the highest amount of quail manure added per week. However, T1, T2 and T3, showed constant growth till the end of the experimental period, with no significant differences observed among them (Figure 1). The growth rate of fish in fertilized tanks was partly attributed to the leftover feed from the quails and the fertilization of the water which stimulated the growth of phytoplankton and zooplankton. In order to reduce expenses on commercial fish feed, supplementary ingredients in use among the farmers have also included: soybeans, maize bran, other various plant proteins, insects and algae. These have grown fish to attain table size of between 100 and 350g. However, it must be emphasized that consumer preference in Zambia differs a lot and size of fish on the market does not matter much.
Results of the experiment showed that in order to achieve acceptable fish growth and survival of fish, 0.48 kg quail manure/week/2m2 should be used as optimum for better growth of fish, although no primary productivity was measured to estimate zooplankton biomass in this study. At that level, growth performance was good and other indicators were well within acceptable range of fish of the same size. Similarly, Nile tilapia (O. niloticus) fingerlings averaging 19.0± 1.0 g in weight were reared at four different concentrations of UIA-N (0.01, 0.05, 0.1 and 0.15 mg/l) besides the control using 15 glass aquaria (40 ×70 ×60 cm) (El-Sherif, and El-Feky, 2008). At the end of the experimental period (after 75 days from the stocking) the final average body weights (FBW) of Nile tilapia (O. niloticus) fingerlings were 37.2, 36.4, 32.5, 26.9 and 37.7 g for UIA-N concentrations of 0.01, 0.05, 0.1, 0.15 and 0.004 mg/l, respectively (El-Sherif, and El-Feky, 2008).
In this study, all treatments, except 5, recorded high survival rate (Table 1), while El-Sherif, and El-Feky (2008) reported that no mortality occurred in any of their experimental groups throughout the experimental period. The use of quail manure which was rich in proteins underwent decomposition and the end product was ammonia which contained unionized ammonia.Ammonia exists in two forms: unionised ammonia (NH3-N), and ionised ammonia (NH4+-N), the sum of these two is called total ammonia nitrogen (TAN) (Molleda, et al., 2007).The relative concentration of ammonia is primarily a function of water pH, salinity and temperature (Pillay and Kutty 2005). The higher toxicity levels of NH3-N and CO2 in water depends on the water’s pH controls acid-base equilibrium; as an example, at 20oC and a pH of 7.0, the mole fraction of NH3-N is 0.004, but at a pH of 10, the NH3-N increase to 0.8 at the same temperature (Timmons et al., 2002).
Based on the results obtained, the ammonia level was highest in T5, which could have been toxic, eventually affecting growth and survival rate of fish in the tank. Higher mortalities in T5 could equally, be attributed to the high amount of ammonia levels recorded, although the values were below unionized Ammonia of 0.05 mg L-1 that may harm fish. Normally, warm water fish are more tolerant to ammonia toxicity than coldwater fish, and freshwater fish are more tolerant than saltwater fish, so in general, NH3-N concentrations should be held below 0.05 mg L-1 and TAN concentrations below 1.0 mg L-1 for long-term exposure (Timmons et al., 2002). During the day especially after adding quail manure some fish would be seen coming to the surface gasping for air, showing signs of loss of appetite and red streaking on the fins, gills turning red at the same time fish appearing lethargic. These results were in line with a study conducted by Ogbonna and Chinomso (2010) on Ammonia poisoning and it was concluded that ammonia poisoning could happen suddenly, or over a period of days. Similarly, a study by EL-Shebly and Gad (2011), indicated that the fish exposed to increased concentrations of ammonia showed the following signs: moved very rapidly, lost equilibrium in water, increase in their movements, ventilation, convulsions, spiral swimming, efforts to swallow air from the surface of water, increase in mucous secretion in the gills and on the body surface, hemorrhage in the gills and darkening on the skin.
Ogbonna and Chinomso (2010) reported that in order to ascertain the cause of the death of these fishes on a fish farm, some selected physicochemical and microbiological parameters were used to determine the concentration which resulted in lethal effect on the fishes. Test results, therefore, confirmed that ammonia concentration of above 0.20 mg L-1 in fish ponds had a tendency to harm the fishes. That could partly be an explanation of why mortalities were recorded in T5 where the toxic unionized Ammonia was 0.0354 mg L-1, which was closer to the lethal amount of 0.05 mg L-1. That amount of ammonia equally, explained the slow growth rate which was recorded in Treatment 5. According to Durborow et al. (1997), ammonia poisoning occurred most often when there was less or no circulation of water in the pond. Fish size was equally affected by ammonia. Smaller sized fish exposed to a higher dosage per body weight unit become more susceptible to unionized ammonia (Piedras et al., 2006). Correspondingly, Cavero et al. (2004) exposed young Arapaima gigas to a concentration of 25 mg/L NH3+ NH4+ or 2 mg/L NH3 for 24 hours and no effect was observed. Survival of fish was more critical mostly during the period just after stocking because by then the fish would have been stressed but had to acclimatize to the new environment. Other than handling, stress can also be caused by the differences in temperature, which could be worsened if the amount of toxic ammonia in the pond was very high as observed in the present study. In the same vein, we could not rule out the low oxygen uptake by fish. According to Mallya and Thorarensen (2007), it was commonly thought that if there was not enough oxygen in the water, then the fish would be seen gasping at the surface but this was a last resort means to breathe. The authors reported that the first indication there may be a dissolved oxygen problem in the water was when the fish become unusually lethargic and stop feeding. As oxygen levels decrease, the fish do not have enough energy to swim and feeding utilises yet more oxygen (Mallya and Thorarensen, 2007).
Water quality parameters remained within the acceptable limits for tilapia growth as described by Boyd (1984). Most of the water quality parameters (DO, pH and temperature) were not significantly different in all the treatment groups except total ammonia-nitrogen. Shepherd and Bromage (1992) reported that carp, catfish and tilapia could withstand Dissolved Oxygen levels of below 2 mg/L provided it was for short periods. Lawson (1994) however, observed that to support life for several hours, a minimum of 1.0 mg/L was required while 1.5 mg/L was necessary to support fish for several days. Tilapia routinely survived dawn dissolved oxygen concentrations of less than 0.5mg/L, considerably below the tolerance limits for other cultured fish. The other minimum water quality parameters reported by Lawson (1994) were as follows: Total ammonia-nitrogen (TAN) less than 1.0 mg/L, Nitrite-nitrogen 0.1mg/L in soft water. The author stated that massive mortality of tilapia occurred within a couple of days at un-ionized ammonia >2 mg/L. Prolonged exposure to un-ionized ammonia levels greater than 1 mg/L causes losses, especially among fry and juveniles in water with low DO (Lawson, 1994).
Conclusion
The study has highlighted the effects of quail manure on growth and survival rate of the fish. The growth rate of fish in fertilized tanks was partly attributed to the leftover feed from the quails and the fertilization of the water which stimulated the growth of phytoplankton and zooplankton. Results of the experiment showed that in order to achieve acceptable fish growth and survival of fish, 0.48 kg quail manure/week/2m2 should be used as optimum for better growth of fish, although no primary productivity was measured to estimate zooplankton biomass in this study. At that level, growth performance was good and other indicators were well within acceptable range of fish of the same size. The study further demonstrated that higher amounts of ammonia affected growth and survival of the fish in treatment 5 (T5), a tank with the highest amount of quail manure added per week.
Acknowledgement
This research was as a result of efforts of many people who despite their prior commitments devoted their time and energy to ensure its success. For this reason we are deeply indebted to the Copperbelt University Management for financial and moral support, staff at the National Aquaculture Research and Development centre (NRDC) and indeed all work colleagues too numerous to mention.
Reference
A.O.A.C (Association of Official Analytical Chemists), 2002, Methods of Analysis. 17th edition. Washington D.C., USA
APHA, 1999, Standard Methods for the Examination of Water and Wastewater, American Public Health Association, American Works Association, Water Environment Federation. 20th Edition. WEF. 601 Wythe Street. Alexandria, VA22314-1994
Barnabe, G., 1994, On growing fish in intensive systems. pp. 349-370. In: G. Barnabe (editor). Aquaculture Biology and Ecology of Cultured Species. New York: Ellis Horwood. 403p
Boyd, C. E., 1984, Water quality in warmwater fishponds. Auburn University, Agricultural Experimental Station, Auburn, Alabama, USA. pp. 359
Durborow, R.M.; Crosby, D.M.; Brunson, M.W., 1997, Nitrite in fish pounds. Southern Regional Aquaculture Center: Publication No 462. 4 pp
El-Sherif, M.S. And El-Feky, Amal M., 2008, Effect of Ammonia on Nile Tilapia (O. niloticus) Performance and some Hematologicِal and Histological measures. 8th International Symposium on Tilapia in Aquaculture 2008. https://ag.arizona.edu/azaqua/ista/ISTA8/mohame-dshreif12.pdf. Retrieved on 13/07/2014
EL-SHEBLY, A.A. and Gad, H.A.M., 2011, Effect of chronic ammonia exposure on growth performance, serum growth hormone (GH) levels and gill histology of Nile tilapia (Oreochromis niloticus). Journal of Microbiology and Biotechnology Research. Scholars Research Library. J. Microbiol. Biotech. Res., 2011, 1 (4):183-197 (http://scholarsresearc-hlibrary.com/archive.html). Retrieved on 13/07/2014.Frank, N., 1998, Ammonia Toxicity to Freshwater Fish the effects of pH and temperature. http://www.thekrib.com/Chemistry/ammonia-toxicity.html. Neil.Frank-at-lambada.oit.unc.edu
Handy, R.D.; Poxton, M.G., 1993, Nitrogen pollution in mariculture toxicity and excretion of nitrogenous compounds by marine fish. Rev. Fish Biol. 3: 205-241
http://dx.doi.org/10.1007/BF00043929
Jobling, M., 1994, Fish bioenergetics. Chapman & Hall, London. 294 pp
Lawson, T.B., 1994, Fundamentals of Aquacultural Engineering. New York: Chapman and Hall. 355p
Lovell, T., 1989, Nutrition and feeding of Fish – Auburn University, Van Nostrand Reinhold, New York
http://dx.doi.org/10.1007/978-1-4757-1174-5
Mallya, Y.J. and Thorarensen, H., 2007, The Effects of Dissolved Oxygen on Fish Growth in Aquaculture. UNU-Fisheries Training Programme. Final Project 2007. P.O. Box 1390, Skulagata 4. 120 Reykjavik, Iceland. http://www.unuftp.is/static/fellows/document/yovita07prf.pdf. Retrieved on 13/07/2014
Molleda, M.I., Thorarensen, H. and Johannsson, R., 2007, Water Quality in Recirculating Aquaculture Systems for Arctic Charr (Salvelinus alpinus L.) Culture. UNU-Fishries Training Programme. Final Project 2007. P.O. Box 1390, Skulagata 4 120 Reykjavik, Iceland.
Nettena, J.J.C, Heide, T. and Smolders, A.J.P., 2013, Interactive effects of pH, temperature and light during ammonia toxicity events in Elodea Canadensis.Chemistry and Ecology, 2013
http://dx.doi.org/10.1080/02757540.2013.769971
Ogbonna, J. F.and Chinomso, A. A., 2010, Determination of the concentration of ammonia that could have lethal effect on fish pond. Department of Petroleum and Gas Engineering, Faculty of Engineering, University of Port Harcourt, Nigeria
Rana Sunil Siriwardena, K.J. and Hasan, M.R., 2009, Impact of rising feed ingredient prices on aquafeeds and aquaculture production. FAO Fisheries and Aquaculture Technique Paper 541. Food and Agriculture Organization of the United Nations Rome, 2009http://www.fao.org/ docrep/012/i1143e/i1143e.pdf. Retrieved on 24/06/2014
Shelton, W.L., 2002, Tilapia culture in the 21st century. p.1-20. In: Guerrero, R.D. III and M.R. Guerrero-del Castillo (eds.). Proceedings of the International Forum on Tilapia Farming in the 21st Century (Tilapia Forum 2002), 184p. Philippine Fisheries Association Inc. Los, Banos, Laguna, Philippines.
Timmons, M.B., Ebeling, J.M., Wheaton, F.W., Summerfelt, S.T. and Vinci, B.J., 2002, Recirculating Aquaculture Systems, 2nd Edition. Cayuga Aqua Ventures, Ithaca, NY 14850, USA. 800 p. NRAC Publication No. 01-002
TUCKER, G.S., 1993, Water Analysis. pp 166-197. In: Stoskopf (editor). Fish Medicine.W.B. Saunders Company. Philadephia. 882p
Steffens, W., 1989, Principles of fish nutrition, West Sussex, Ellis Horwood Ltd., 384 pp
Pillay, T.V.R., 1990, Aquaculture; Principles and Practices –Blackwell publishing Ltd, Oxford UK.
Pillay, T.V.R. and Kutty, M.N., 2005, Aquaculture, Principles and Practices, 2nd Edition. Blackwell Publishing Ltd, Oxford, UK. 630 p

Thorarinsdottir, R.I, Jokumsen, A., Björnsson, B.T. and Prof. Ole Torrissen, O., 2011, Local raw materials for production of fish feed for aquaculture Nordic Innovation Centre - Project no. 10102 - June 2011. Islensk Matorka ehf. Iceland DTU-Aqua, Denmark University of Gothenburg, Sweden University of Nordland, Norway. Retrieved on 20/06/2014

International Journal of Aquaculture
• Volume 4
View Options
. PDF(1288KB)
. FPDF
. HTML
. Online fPDF
Associated material
. Readers' comments
Other articles by authors
. Masautso E. Sakala
. Confred G. Musuka
Related articles
. Ammonia
. Effect
. Growth
. Survival rate
. Quail manure
. Concrete tanks
Tools
. Email to a friend
. Post a comment

Terms and Conditions | Returns and Refund Policy | Privacy Statement | Information for Advertisers | Contact Aqua Publisher

Copyright © Sophia Publishing Group Inc.